Failure analysis of second-hand forklifts, sometimes the temperature gradually cools down, and the climate has also changed significantly. In the summer and autumn seasons, special attention should be paid to maintenance of used forklifts. It is recommended that the maintenance of second-hand forklifts in this quarter should do the following.
Vehicle exterior maintenance: In the autumn morning and dusk, there are many dewdrops, and the appearance of the forklift is often very wet. If the body has significant scratches, it should be painted in time to avoid moisture and rust on the scratched parts. Due to the corrosion of acid rain and summer rain, direct light in summer, the paint surface of the body will oxidize inevitably. In the cold season,
It is quite good to make the appearance of the forklift by cleaning, maintaining and repairing the paint.
Tire protection: In the safe driving of forklifts, tires play an important role. In summer, due to the high temperature, you should always check the tire pressure. You can't make the tire pressure too high, otherwise, there will be a risk of tire puncture, and in autumn, due to the relatively low temperature, the tire will supply the pressure and keep it within the regular range At the same time, the pressure of the internal air should also be checked for scratched tires. Due to the simple rubber crusting and brittle tires in the autumn and winter seasons, the tires are easy to leak.
Engine room protection: check whether the engine oil, brake fluid and antifreeze in the engine room are sufficient, change, replace the circulation, and whether the oil resembles the blood of the vehicle. It is necessary to change the circulation to ensure the circulation of the oil circulation. Brake system maintenance: The temperature difference between autumn and night is large, and the body is simply expanded and contracted. It is often necessary to check whether the brake is weak, drifting, and whether the strength of the brake pedal has been changed. It is necessary to clean the brake system of the entire pipeline.
Warm air duct and fan protection: If your forklift is equipped with a warm air duct or fan, after a summer, or preparing for the coming cold winter, autumn is quite suitable for viewing these devices, the wind is normal, Whether it is the exhaust gas detection line aging, etc., if there is any problem, it can be dealt with in time. Intake pipe or grille maintenance: check whether these parts are debris, if there is debris, you can use compressed air to blow off the dust, in addition, in the case of engine cooling, the above area can be used to clean from the inside to the outside .
